Product ID:PRIMER, WASH PRETREATA FORM 117 FOR METALS
MSDS Date:03/12/1991
FSC:8030
NIIN:00-281-2726
Kit Part:Y
MSDS Number: BKJHZ

PRATT AND LAMBERT INC

16116 E 13TH ST
WICHITA, KS 67201
US

Emergency Phone: 800-255-3924

Info Phone: 316-733-1361

Preparer: W. A. ELLISON

Cage: 61196

PRATT AND LAMBERT INC

6027 CLEVELAND, OH 44101-1027 US

Telephone: 216-566-2902

Cage: 61196

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 60%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

ETHYL ALCOHOL (ETHANOL)

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 5%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9192

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ZINC CHROMATE

CAS: 13530-65-9

RTECS: GB3290000

Fraction By Weight: 5%

OSHA PEL 0.1 MG/M3 (CRO3)

ACGIH TLV: 0.01MG/M3(CR)A1;9192

PHOSPHORIC ACID (SARA III)

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 5%

OSHA PEL 1 MG/M3/3 STEL

ACGIH TLV: 1 MG/M3/3 STEL; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

5.91 LB/GL LESS WATER & NPRS*; 709 G/L LESS WATER;

RTECS: 9999999VO

56.59 LB/GAL SOLIDS; 6791 G/L SOLIDS; CALCULATED

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:IRRITATION (GASTROINTEST, UPPER RESPIR
TRACT, EYE, SKIN). SEVERE BURNS: MOUTH, ESOPHAGUS, STOMACH. LUNG
ASPIR: CHEM PNEUMONITIS. DEEP INHALE MAY CAUSE PULMONARY EDEMA,
POSSIBLY DELAYED IN ONSET. CORNE AL DAMAGE. SKIN ABSORPTION, BURNS.
OVEREXPO: LUNG CANCER. REPEAT/PROLONG EXPOSURE MAY CAUSE DERMATITIS
& TOOTH EROSION.
Explanation of Carcinogenicity:ZINC CHROMATE IS LISTED AS A POTENTIAL
CARCINOGEN BY THE IARC.
Effects of Overexposure:INGEST: STOMACH PAIN, NAUSEA AND VOMITING.
INHALE: COUGH, BURNING THROAT, CHOKING SENSATION. METAL FUME FEVER:
FLU-LIKE, FEVER, CHILLS, COUGH.
Medical Cond Aggravated by Exposure:SOLVENTS HAVE BEEN ASSOCIATED WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.

First Aid:INGEST: DO NOT INDUCE VOMITING. GIVE 1-2 GLASSES WATER.
NOTHING BY MOUTH TO UNCONSCIOUS PERSON. CALL POISON CONTROL, EMERG
ROOM OR DOCTOR IMMED. INHALE: REMOVE TO FRESH AIR IMMEDIATELY. GIVE
CPR IF NE EDED. KEEP WARM & QUIET. GET IMMED MEDICAL AID. EYE:
FLUSH THOROUGHLY W/LARGE AMOUNTS WATER FOR 15 MIN. GET MEDICAL AID.
SKIN: FLUSH CONTAM SKIN WHILE REMOVING CONTAMINATED CLOTHES. GET
MEDICAL AID.

Flash Point:53.0F,11.7C
Autoignition Temp:Autoignition Temp Text:572F
Lower Limits:1.4
Upper Limits:19.0
Extinguishing Media:USE NFPA CLASS B(CO2, ALL PURPOSE DRY CHEMICAL OR
ALCOHOL FOAM)FOR LIQUID FIRES. POLYMER FOAM PREFERRED FOR LARGE
FIRES.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE, USE TO COOL
CONTAINERS (FOG NOZZLE PREFERABLE) TO PREVENT PRESSURE BUILD-UP &
AUTO-IGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:DURING EMERGENCY CONDITIONS, OVEREXPOSURE
TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY
NOT BE IMMEDIATELY APPARENT. GET MEDICAL ATTENTION.

Spill Release Procedures:WEAR PROTECT EQUIPMENT/CLOTHES. KEEP
SPECTATORS AWAY. ELIMINATE IGNITE SOURCES. DIKE/CONTAIN/REMOVE
W/INERT MAT'L (EARTH, ETC). USE COVERED METAL CNTNRS FOR
RECOVERY/DISPOSAL. USE NON-SPARKING TOOLS. PREVENT CONTAM OF
SEWERS, STREAMS AND GROUNDWATER.

Handling and Storage Precautions:DO NOT STORE ABOVE 100F. LARGE
QUANTITY STORAGE: COMPLY WITH OSHA 29CFR1910.106. DO NOT TAKE
INTERNALLY. KEEP FROM CHILDREN. DO NOT REUSE CONTAINERS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED AND BONDED TO THE
RECEIVING CONTAINER. DO NOT WELD, BRAZE OR CUT ON EMPTY CONTAINER.
NEVER USE PRESSURE TO EMPTY. DRUM IS NOT A PRESSURE VESSEL. CLOSE
CONTAINER AFTER EAC H USE.

Respiratory Protection:RESTRICTED AREA: NIOSH APPR'D CHEMICAL CARTRIDGE
RESPIRATOR. SPRAYING: MECHANICAL PREFILTER MAY BE REQUIRED.
CONFINED AREAS: NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR.
EXCEEDED TLV AREA: NIOSH/MSHA APPR'D RESPIRATOR W/RIGHT PROTECT
FACTOR
Ventilation:GENERAL DILUTION/LOCAL EXHAUST VENTILATION IN SUFFICIENT
VOLUME & PATTERN TO KEEP CONCENTRATIONS BELOW EXPOSURE LIMITS.
Protective Gloves:REPEAT/PROLONG: IMPERMEABLE GLOVES.
Eye Protection:SAFETY GLASSES,SPLASH GOGGLES,FACESHIELD
Other Protective Equipment:EYEWASH STATION, SAFETY SHOWER.
Supplemental Safety and Health
BRAZING OR TORCH CUTTING MATERIALS COATED WITH THIS PRODUCT MAY PRODUCE
METAL OXIDES. REMOVE DECOMPOSITION PRODUCTS THAT ARE GENERATED WHEN
WELDING, CUTTING, OR BRAZING OBJECTS COATED WITH THIS PRODUC T.

HCC:F2
Boiling Pt:B.P. Text:171 TO 500F
Melt/Freeze Pt:M.P/F.P Text:-50F,-46C
Decomp Temp:Decomp Text:1832F,1000C
Vapor Pres:44
Vapor Density:> AIR
Spec Gravity:0.9
pH:4-7 *
Viscosity:< 200 CST
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, SOLVENT ODOR
Percent Volatiles by Volume:89

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. ACETYL CHLORIDE.
Stability Condition to Avoid:AVOID EXCESS HEAT (>100F) & IGNITION
SOURCES.
Hazardous Decomposition Products:BURNING WILL PRODUCE SMOKE, CARBON
MONOXIDE, CARBON DIOXIDE. OXIDES OF: CHROMIUM, ZINC MAY BE
GENERATED.

Waste Disposal Methods:FOLLOW FEDERAL, STATE & LOCAL LAWS. INCINERATE
IN EPA PERMITTED FACILITY. DO NOT INCINERATE CLOSED CONTAINERS. USE
PRECAUTIONS FOR DISPOSAL OF HAZARDOUS MATERIALS-D001. USE HAZARDOUS
WASTE LANDFILL FO R USED ABSORBENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.